Experimental Study on Weakening Hard Roof by Pre-splitting Blasting During Initial Mining at Fully-mechanized Caving Face

LI Chao; KANG Tianhe; ZHANG Bin

Safety in Coal Mines > 2015 > 46(10): 28-31.

LI Chao, KANG Tianhe, ZHANG Bin. Experimental Study on Weakening Hard Roof by Pre-splitting Blasting During Initial Mining at Fully-mechanized Caving Face[J]. Safety in Coal Mines, 2015, 46(10): 28-31.

Citation:

Experimental Study on Weakening Hard Roof by Pre-splitting Blasting During Initial Mining at Fully-mechanized Caving Face

More Information

Published Date: October 19, 2015

Graphical Abstract

Abstract

Abstract

To solve the problems such as rock burst, gas accumulation and the low recovery rate of top coal during the initial mining of top coal caving mining caused by hard roof which is hard to break down, the design and field test of weakening roof at 3301 fully-mechanized caving face of Tang'an Coal Mine with the method of deep-hole pre-splitting blasting was set up. The results show that the optimal blasting parameters such as blast hole spacing, hole elevation were reasonable and the blasting can make the roof pre-splitting and change its stress state; the initial roof fracture step distance was shortened by 38.43 m, and the yield increased by 22 801 t. The caving of main roof in advance solves problems of rock burst and gas accumulation in gob result from ventilation difficulties.
- hard roof,
- fully-mechanized caving face,
- deep-hole pre-splitting,
- blasting parameter,
- initial roof fracture step distance,
- rock burst,
- weakening roof

FullText(HTML)

References (11)

References

[1]	史元伟. 采煤工作面围岩控制原理和技术[M].徐州：中国矿业大学出版社，2005：46-50.
[2]	宋永津. 注水、压裂、弱化-控制煤层坚硬难冒顶板技术[M].北京：煤炭工业出版社，2002：6-9.
[3]	陈炎光，钱鸣高. 中国煤矿采场围岩控制[M].徐州：中国矿业大学出版社，1994：18-21.
[4]	崔永杰，孙琪，郑跃兵，等. 坚硬顶板弱化处理防止瓦斯骤然涌出[J].煤炭技术，2011，30（12）：80-82.
[5]	沈玉旭，康天合，杨永康，等. 综放初采顶板深孔预裂爆破的研究与实践[J].矿业研究与开发，2013，33（4）：122-125.
[6]	王岩，梁冰，袁欣鹏. 易自然煤层综放工作面安全开采方法研究[J].采矿与安全工程学报，2012，29（5）：730-734.
[7]	郭卫彬，刘长友，吴锋锋，等. 坚硬顶板大采高工作面压架事故及支架阻力分析[J].煤炭学报，2014，39（7）：1212-1219.
[8]	康天合，柴肇云，李义宝，等.底层大采高综放全厚开采20 m特厚中硬煤层的物理模拟研究[J].岩石力学与工程学报，2007，26（5）：1065-1072.
[9]	贾喜荣. 岩石力学与岩层控制[M].徐州：中国矿业大学出版社，2010：67-70.
[10]	钱鸣高，刘听成. 矿山压力及其控制[M].北京：煤炭工业出版社，1991：45-46.
[11]	郭德勇，商登莹，吕鹏飞，等. 深孔聚能爆破坚硬顶板弱化试验研究[J].煤炭学报，2013，38（7）：1149.

[1]	CHENG Lixing. Parameter optimization analysis and mechanical property test research based on reaming anchorage[J]. Safety in Coal Mines, 2023, 54(7): 196-204.
[2]	LIU Yaxin, XING Minglu, LIU Pengcheng, FU Yankun. Study on fine numerical simulation of pull-out test process of anchor rock with rebar anchor[J]. Safety in Coal Mines, 2022, 53(3): 66-74.
[3]	LIU Hongwang. Failure Analysis of Anchor Cable Tray of Mining Roadway in Island Working Face[J]. Safety in Coal Mines, 2016, 47(11): 204-207.
[4]	SUN Haiyang, WANG Lianguo, LU Yinlong, HUANG Yaoguang. Numerical Simulation and Parameter Optimization of Advance Anchor Bolt Support in Fault[J]. Safety in Coal Mines, 2015, 46(8): 205-208.
[5]	WANG Lin, WANG Guanghong. Numerical Simulation on Failure Characteristics of Mining Coal Seam Floor[J]. Safety in Coal Mines, 2015, 46(7): 211-214.
[6]	JIA Xige, LI Yingming, MENG Xiangrui, WANG Yuliang. Failure Mechanism Analysis and Structural Optimization of Glass Fiber Reinforced Plastics Bolting Tray Based on ANSYS[J]. Safety in Coal Mines, 2015, 46(5): 212-215.
[7]	ZHAO Yajun, YANG Yong, HE Long, WANG Wei, LEI Ming, YAN Xiaonan. Numerical Simulation of Reinforcement Arch Theory of High Pre-stress Anchor Bolt[J]. Safety in Coal Mines, 2014, 45(9): 47-50.
[8]	LIU Yi-xin. Numerical Simulation of Mining Overburden Failure Law[J]. Safety in Coal Mines, 2013, 44(12): 198-200.
[9]	ZHANG Lian-ying, MA Chao, LI Yan. Numerical Simulation of Bolting Support Mechanism[J]. Safety in Coal Mines, 2013, 44(9): 71-73.
[10]	MA Shao-jie. Numerical Simulation Study on Overlying Strata Failure of Coal Mining[J]. Safety in Coal Mines, 2012, 43(12): 54-56.

Cited By

Cited by

Periodical cited type(9)

1.	张周爱，李新鹏，缪卫峰，周志伟，史广诚. 雨水作用下缓倾角岩层露天煤矿凸边坡变形机理研究. 中国矿业. 2024(S1): 128-136+142 .
2.	陈德付. 基于流固耦合的露天矿易滑区边坡稳定性分析. 露天采矿技术. 2024(04): 74-78 .
3.	吴奇靖，赵永茂. 降雨作用下含软弱带斜坡稳定性研究. 福建建材. 2024(08): 74-77 .
4.	朱振. 基于FLAC某边坡失稳数值模拟分析. 陕西水利. 2023(02): 21-22+27 .
5.	罗科，高瑜，张斌. 煤层自燃对高陡露天矿边坡稳定性的影响与防治对策. 煤矿安全. 2022(01): 191-197 . 本站查看
6.	朱涛，尹翔，王成汤，闵弘，王浩，陈娱，何俊霖. 西昌太和矿北采场滑坡变形演化规律及成因机制研究. 岩土力学. 2022(S2): 392-400+413 .
7.	孙世国，高晨，冯少杰，邓王倩. 水厂铁矿河西渣土场雨季滑移变形规律研究. 矿业研究与开发. 2022(12): 50-55 .
8.	吴榕真，舒应秋，李志强，关云泽. 基于水影响作用下的露天煤矿边坡稳定性研究. 露天采矿技术. 2021(03): 26-29 .
9.	田光，韩流，舒继森，杨日. 孔隙水压力重分布对排土场边坡稳定性影响规律研究. 煤矿安全. 2021(08): 239-242+247 . 本站查看

Other cited types(3)

Get Citation

XML

Article views (266) PDF downloads (1) Cited by(12)

Turn off MathJax

Article Contents

Abstract

References

Experimental Study on Weakening Hard Roof by Pre-splitting Blasting During Initial Mining at Fully-mechanized Caving Face

Abstract

References

Related Articles

Cited by

Periodical cited type(9)

Other cited types(3)

Catalog

Experimental Study on Weakening Hard Roof by Pre-splitting Blasting During Initial Mining at Fully-mechanized Caving Face

Abstract

References

Related Articles

Cited by

Periodical cited type(9)

Other cited types(3)

Catalog

Export File

Citation

Format

Content