- Chinese Core Periodicals
- Chinese Core Journals of Science and Technology
- RCCSE Chinese Authoritative Academic Journals
| Citation: |
WANG Zhixin, LIU Liren, ZHANG Xiaotao, et al. Influence mechanism of cutting turbulent wind on coal dust lateral dispersal in large mining height fully mechanized mining face[J]. Safety in Coal Mines, 2024, 55（4）: 72−78. DOI: 10.13347/j.cnki.mkaq.20231330
|
The large size shearer drum in the large mining height working face generates more obvious turbulent wind in cutting the coal body, which causes the local wind speed of the working face to change, and the horizontal diffusion of dust particles to the sidewalk area. In order to clarify the influence mechanism of cutting turbulent wind on the dust mass concentration distribution along the working face with large mining height, a coupled mathematical model of airflow and dust was constructed by numerical simulation method for 85219 working face, and the airflow distribution, dust migration and dust mass concentration distribution at the height of the breathing zone were studied. The results show that, compared with the flow field under system ventilation only, the partial velocity of negative drift increases significantly at the front and back of the drum and at the moving frame, and a “wind drift zone” with negative drift wind velocity value of -1.06 m/s is generated near the drum. Under the disturbance of cutting turbulent wind, dust masses with a mass concentration of more than 151.85 mg /m3 at the front and back rollers have transverse dispersion to the sidewalk area. In the state of downwind coal cutting, the ability of cutting turbulent wind at the front rollers to induce transverse dispersion of cutting coal dust is higher than that at the back rollers. The dust mass concentration in the breathing zone of the sidewalk near the front roller was increased by 64.77% compared with the condition of system ventilation only. The comparison between the simulated data and the field-measured data shows that the relative error is less than 12.57%, and the simulated data is relatively accurate. Based on this, a dust-bearing air flow dust control device shearer is proposed, which is applied in the field and its dust control effect is tested. The dust removal efficiency in the working area of the working face is more than 78.31%, and the total dust removal efficiency is more than 89.93%.
| [1] |
袁亮. 煤矿粉尘防控与职业安全健康科学构想[J]. 煤炭学报,2020,45(1):1−7.
YUAN Liang. Scientific conception of coal mine dust control and occupational safety[J]. Journal of China Coal Society, 2020, 45(1): 1−7.
|
| [2] |
许圣东,李德文,陈芳. 8 m大采高综采工作面风流及呼吸尘分布规律数值模拟[J]. 煤矿安全,2018,49(12):160−163.
XU Shengdong, LI Dewen, CHEN Fang. Numerical simulation on distribution laws of air and respirable dust at fully mechanized face with 8 m mining height[J]. Safety in Coal Mines, 2018, 49(12): 160−163.
|
| [3] |
李德文,赵政,郭胜均,等. “十三五”煤矿粉尘职业危害防治技术及发展方向[J]. 矿业安全与环保,2022,49(4):51−58.
LI Dewen, ZHAO Zheng, GUO Shengjun, et al. “13th Five-Year Plan” coal mine dust occupational hazard prevention and control technology and development direction[J]. Mining Safety & Environmental Protection, 2022, 49(4): 51−58.
|
| [4] |
庞杰文,谢建林,李川田,等. 大采高综采工作面粉尘分布特征研究[J]. 煤炭科学技术,2017,45(3):78−83.
PANG Jiewen, XIE Jianlin, LI Chuantian, et al. Study on dust distribution features of high cutting fully-mechanized coal mining face[J]. Coal Science and Technology, 2017, 45(3): 78−83.
|
| [5] |
王存飞. 大采高综采工作面作业区域粉尘溯源研究[J]. 矿业安全与环保,2022,49(2):29−34.
WANG Cunfei. Study on dust tracing in working area of fully mechanized mining face with large mining height[J]. Mining Safety & Environmental Protection, 2022, 49(2): 29−34.
|
| [6] |
周刚,张琦,白若男,等. 大采高综采面风流-呼尘耦合运移规律CFD数值模拟[J]. 中国矿业大学学报,2016,45(4):684−693.
ZHOU Gang, ZHANG Qi, BAI Ruonan, et al. CFD simulation of air-respirable dust coupling migration law at fully mechanized mining face with large mining height[J]. Journal of China University of Mining & Technology, 2016, 45(4): 684−693.
|
| [7] |
杜善周,莫金明,王全龙,等. 大采高综采工作面粉尘运移分布规律及机载除尘器关键工艺参数研究[J]. 矿业安全与环保,2020,47(2):45−51.
DU Shanzhou, MO Jinming, WANG Quanlong, et al. Research on key process parameters of airborne dust collector based on distribution law of dust movement in fully mechanized working face with large mining height[J]. Mining Safety & Environmental Protection, 2020, 47(2): 45−51.
|
| [8] |
徐青云,白志云,李锦波. 大采高综采工作面多尘源风流-粉尘分布规律研究[J]. 矿业安全与环保,2020,47(5):56−59.
XU Qingyun, BAI Zhiyun, LI Jinbo. Air flow-dust distribution law of multi-dust sources in fully mechanizedworking face with large mining height[J]. Mining Safety & Environmental Protection, 2020, 47(5): 56−59.
|
| [9] |
张辛亥,尚治州,冯振,等. 大采高综采工作面风流-呼吸带粉尘分布数值模拟[J]. 安全与环境学报,2021,21(2):570−575.
ZHANG Xinhai, SHANG Zhizhou, FENG Zhen, et al. Numerical simulated distribution of the airflow and dust movement in the respiratory zone at the fully mechanized mining face with great mining height[J]. Journal of Safety and Environment, 2021, 21(2): 570−575.
|
| [10] |
莫金明,马威. 大采高综采工作面负压除尘微雾净化装置应用研究[J]. 煤炭学报,2023,48(3):1267−1279.
MO Jinming, MA Wei. Negative-pressure dust removal and micro-mist purification device application in fully-mechanised mining faces with a large mining height[J]. Journal of China Coal Society, 2023, 48(3): 1267−1279.
|
| [11] |
蒋仲安,杨斌,张国梁,等. 高原矿井掘进工作面截割粉尘污染效应及通风控尘参数分析[J]. 煤炭学报,2021,46(7):2146−2157.
JIANG Zhongan, YANG Bin, ZHANG Guoliang, et al. Analysis of dust pollution effect of cutting dust and ventilation control parameters at the heading face in plateau mines[J]. Journal of China Coal Society, 2021, 46(7): 2146−2157.
|
| [12] |
张国梁,蒋仲安,杨斌,等. 高原环境下矿井最低排尘风速的数值模拟[J]. 煤炭学报,2021,46(7):2294−2303.
ZHANG Guoliang, JIANG Zhongan, YANG Bin, et al. Numerical simulation of the minimum mine dust exhausting wind speed under high altitude environment[J]. Journal of China Coal Society, 2021, 46(7): 2294−2303.
|
| [13] |
陈芳. 8 m大采高综采工作面风流分布规律数值模拟[J]. 煤矿安全,2019,50(11):185−188.
CHEN Fang. Numerical study on airflow distribution law in 8 m large mining height fully-mechanized face[J]. Safety in Coal Mines, 2019, 50(11): 185−188.
|
| [14] |
孙彪,程卫民,王昊,等. 综采工作面滚筒旋流风对截割煤尘侧向逸散规律的影响[J]. 煤炭学报,2018,43(8):2269−2279.
SUN Biao, CHENG Weimin, WANG Hao, et al. Influence of rotary wind from drums on lateral dissipation law of coal dust from cutting at fully-mechanized mining face[J]. Journal of China Coal Society, 2018, 43(8): 2269−2279.
|
| [15] |
苏士龙,郝永江. 大采高综采工作面PM5和PM10粉尘分布规律[J]. 煤矿安全,2020,51(7):210−214.
SU Shilong, HAO Yongjiang. Dust distribution of PM5 and PM10 in large mining height fully-mechanized face[J]. Safety in Coal Mines, 2020, 51(7): 210−214.
|
| [16] |
荆德吉,马纪闯,张天,等. 选煤厂并行运输带运转系统煤尘污染规律研究[J]. 煤矿安全,2023,54(1):16−21.
JING Deji, MA Jichuang, ZHANG Tian, et al. Study of coal dust pollution law of parallel belt conveyor running system in coal processing plant[J]. Safety in Coal Mines, 2023, 54(1): 16−21.
|
| [1] | WANG Zhengyi, HE Jiang. Mechanism of coal-rock dynamic disasters in complex geological structure areas and its prevention[J]. Safety in Coal Mines, 2021, 52(9): 204-210. |
| [2] | GAN Lintang. Coal and rock dynamic disaster analysis in Huainan Mining Area based on key stratum control principle[J]. Safety in Coal Mines, 2021, 52(7): 187-192. |
| [3] | WANG Zhen, REN Gaofeng, ZHANG Congrui, ZHANG Jianfeng. Dynamic Response Characteristics of Shock Air Wave Disaster in Gob Failure Process[J]. Safety in Coal Mines, 2019, 50(6): 45-49. |
| [4] | GAO Zhenyong, WU Guangyu, LI Yue. Influence of Low Temperature Oxidation of Coal Body on Dynamic Disasters of Coal and Rock During Coal Seam Gas Extraction[J]. Safety in Coal Mines, 2017, 48(11): 29-32. |
| [5] | WANG Zhen. Discussion on Classification and Identification Method for Dynamic Disasters of Coal and Rock[J]. Safety in Coal Mines, 2017, 48(6): 176-179. |
| [6] | CUI Feng, LAI Xingping, CAO Jiantao, SHAN Pengfei. Occurrence Mechanism and Control Strategies of Mine Dynamic Disaster[J]. Safety in Coal Mines, 2017, 48(1): 191-194,198. |
| [7] | GENG Youming. Mechanism of Compound Dynamic Disaster and Integrated Prevention Technology in Deep Mine[J]. Safety in Coal Mines, 2016, 47(11): 73-76. |
| [8] | SHI Xianfeng, QU Xiaocheng, WEI Quande, XU Yongyong, FENG Guochun, DONG Qiang, JIN Xianru. Treatment Research on Dynamic Disaster Caused by Hard Roof Multi-seam Mining[J]. Safety in Coal Mines, 2016, 47(6): 33-35,40. |
| [9] | GAO Bao-bin, MI Xiang-fan, ZHANG Rui-lin. Research Status and Prospect of Compound Dynamic Disaster of Deep Mining in Coal Mine[J]. Safety in Coal Mines, 2013, 44(11): 175-178. |
| [10] | JIN Pei-jian, WANG En-yuan, SONG Da-zhao, HUANG Ning, WANG Si-heng. Experimental Study on Coal Rock Electromagnetic Radiation Laws Under Uniaxial Cyclic Loading[J]. Safety in Coal Mines, 2013, 44(5): 46-48. |
Supported by: Beijing Renhe Information Technology Co., Ltd. 
DownLoad: